Products > Integrated Conditioning Acquisition & Control Systems > Integrated Conditioning Acquisition & Control System Enclosures > 6005E  
Download PDF Download PDF     Printable Page     Email Email This Page     Save To Favorites Save To Favorites

Model 6005E, Enclosure 8-Slot, 12 VDC, Ethernet Data & Control Interface



Features

  • DC Enclosure for 8 I/O Modules
  • Ethernet Interface provides 5+ MS/s aggregate data rate
  • Calibration voltage distribution
  • Alarm busses for control external equipment
  • Optional on-board data storage
  • Built-in fans and front mounted connections

Description

The 6005E enclosure has 8 slots for Series 6000 input and output modules with a gigabit Ethernet interface for programming, control and data output. An internal Control & Data Processor (Model 6096) provides an Ethernet interface to the remote Operators Workstation. 6005U is DC operated for mobile applications.

All connections are made on the front allowing the 6005E to be located in the tightest of spaces. It has integral fans that supply cooling air to the modules and power supply. Power is 10 to 20 VDC with 21 to 32 VDC also available. An included power adapter is provided for operation from 120/240 VAC.

Data Redundancy is optionally available. A 2.5" HD (Module 6095) mounts on the USB controller board in each 6010U enclosure and provides a redundant recording point for the DAS. In the unlikely event the Operators Workstation or DAS Software fails, data will continue to record in each enclosure. Data can be recovered from the system post-test.

The Operators Workstation (PCCOWU-LT) is the primary control and data recording point for the Series 6000 DAS. The PCCOWU-LT is typically a laptop, connected to the 6005E's Ethernet port and runs PI660 Data Acquisition Software for system setup, calibration, display, recording, distribution and export.






Overview  · Data Format  · Data Interface  · Operation  · Connections  · Specifications  · Mechanical  · Operators Workstation (PCCOWU-LT) (Optional)  · Ordering Information 

Overview

Enclosure Specifications

Series 6000 and 6100 Enclosures are common between the two product lines. Integrated A/D, data and sample rates noted in enclosure specifications apply only to the Series 6000 systems.


Data Format

Data Word

16 or 32-bits, 2's complement binary.

Scan Table

Maximum format length is 65,536 samples.

Sample Rates

Multiple sample rates consisting of the highest sample rate divided by binary numbers. Highest sample rate is programmable with 1 uS resolution.


Data Interface

Output Rate

Processor dependent, typically over 5 million 16-bit samples/second.

Latency

Processor and scan table dependent, typically less than 5 milliseconds.

Clock Stability

100 ppm over temperature range.


Operation

Protocol

Gigabit Ethernet

Software

Window's driver (Both 32 and 64-bit) provides high-level operating command set. Fully compatible with all implementations of PI660 operating software.

Control Inputs

TTL inputs for Start, Stop and Trigger assert flags in the header of output data that initiate software control operations.

Alarms

Warning and alarm buses may be independent or shared between enclosures and may initiate an output from a digital I/O type module.


Connections

Calibration

15-Pin Type D mounted on rear panel. Mating connector supplied.

Control

15-Pin Type D mounted on rear panel. Mating connector supplied.

Synchronization

Sampling clock synchronization for multiple rack systems. RJ45 connector on controller board. Category 5, 2-meter cable supplied.

USB

2-meter cable supplied.

Ethernet

Gigabit Ethernet


Specifications

Ethernet (Connections)

RJ45 connector on front panel.

Accessories

6085 - Connector Interface Panel for 6005 Enclosures. I/O module specific.


Mechanical

Power Input

10 to 20 VDC. (21 to 32 VDC available on special order)

Operating Temperature (Mechanical)

0 to +50 ºC

Humidity

95% without condensation.

Width

View
13.4 in

Height

View
10.5 in

Depth

View
16.7 in

Weight

Approximately 30 pounds with all channel modules.


Operators Workstation (PCCOWU-LT) (Optional)

Operating System

Windows 7, 64-Bit (others Windows OS configurations available)

Processor & Memory

Intel Core i5 or better. 2 GB RAM

Media

160 GB SSD or better and CD/DVD. Larger disk drives available.

Display

15 in

Power

115 or 230 VAC, 47 to 63 Hz.

Operating Temperature

0 to +50 ºC

Size

Laptop (other configurations available)


Ordering Information 

Ordering Information

6005E - Enclosure, 8-slot, 12VDC Ethernet Interface
6095 - Redundant Hard Drive
PCCOWU-LT - Operators Workstation. Laptop.


 DOWNLOADS 

Model 6005E
(PDF, 84KB)


© 2015, Pacific Instruments, Inc. Catalog IndexPrivacy PolicySite Map