Products > Integrated Conditioning Acquisition & Control Systems > Integrated Conditioning Acquisition & Control System Enclosures > 6000E  
Download PDF Download PDF     Printable Page     Email Email This Page     Save To Favorites Save To Favorites

Model 6000E, Enclosure 16-Slot, Ethernet Data & Control Interface


  • Enclosure for 16 I/O modules
  • Ethernet Interface provides up to 4.8 MS/s aggregate data rate
  • Calibration voltage distribution
  • Alarm busses for control of external equipment
  • Optional on-board data storage
  • Built-in fans and cable tray


The 6000E enclosure has 16 slots for Series 6000 input and output modules with a gigabit Ethernet interface for programming, control and data output. An internal Control & Data Processor (Model 6096) provides an Ethernet interface to the remote Operators Workstation. The 6000E has 5 USB 2.0 connectors on the rear panel. This allows multiple Model 6000U (up to 63) enclosures to be used for system expansion. A sample clock bus is provided for multi rack installations.

The enclosures are 8U 19-inch rack-mount. The enclosures have integral fans providing air circulation and an internal cable tray that routes the input and output cables from the front of the installed modules to exit the rear of the enclosure.

Data Recording Redundancy is optionally available. A 2.5" HD (Model 6095) mounts on the USB controller board in each 6000U enclosure and provides a redundant recording point for the DAS. In the unlikely event the Operators Workstation or DAS Software fails, data will continue to record in each enclosure and can be recovered from the system post test.

The Operators Workstation (PCCOWU-DHD) is the primary control and data recording point for the Series 6000 DAS. The PCCOWU-DHD is typically installed in the control room and runs PI660 Data Acquisition Software for system setup, calibration, display, recording, distribution and export.

Overview  · Data Format  · Data Interface  · Operation  · Connections  · Mechanical  · Operators Workstation (PCCOWU) (Optional)  · Ordering Information 


Enclosure Specifications

Series 6000 and 6100 Enclosures are common between the two product lines. Integrated A/D, data and sample rates noted in enclosure specifications apply only to the Series 6000 systems.

Data Format

Data Word

16 or 32-bits, 2's complement binary.

Scan Table

Maximum format length is 65,536 samples.

Sample Rates

Multiple sample rates consisting of the highest sample rate divided by binary numbers. Highest sample rate is programmable with 1 uS resolution.

Data Interface

Output Rate

Processor dependent, up to 4.8 million 16-bit samples/second (4.8 MS/s).


Processor and scan table dependent, typically less than 5 milliseconds.

Clock Stability

100 ppm over temperature range.



Gigabit Ethernet


Windows 10 64-bit driver provides a high-level operating command set. Fully compatible with all implementations of PI660 operating software.

Control Inputs

TTL inputs for Start, Stop and Trigger assert flags in the header of output data that initiate software control operations.


Warning and alarm buses may be independent or shared between enclosures and may initiate an output from a digital I/O type module.



15-Pin Type D mounted on rear panel. Mating connector supplied.


9-Pin Type D mounted on rear panel. Mating connector supplied.


Sampling clock synchronization for multiple rack systems. RJ45 connector on controller board. Category 5, 2-meter cable supplied.


5 USB 2.0 ports on rear panel for system expansion.

Ethernet (Connections)

RJ45 connector on rear panel.


Power (Mechanical)

115 or 230 VAC, 110%, 47 to 63 Hz, 400 Watts.

Operating Temperature (Mechanical)

0 to +50 ºC


95% without condensation.


Normal shipping and handling of laboratory instruments.


19 in


14 in


23 in


Approximately 85 pounds with all channel modules

Operators Workstation (PCCOWU) (Optional)

Operating System

Windows 10, 64-Bit.

Processor & Memory

Intel Core i7 or better. 32GB RAM.


512GB SSD or better and CD/DVD. Dual SSD Option. Larger disk drives available.


Gigabit Ethernet


Dual 24" Widescreen for PCCOWU-DHD. No Display for CDP. Larger, distributed or multi-monitor configurations available.


115 or 230 VAC, 47 to 63 Hz.

Operating Temperature

0 to +50 ºC


2U high, 19 in. Rack Mount. (other configurations available)

Ordering Information 

Ordering Information

6000E - Enclosure, 16-slot, Ethernet Interface
6095 - Redundant Hard Drive
CDP-1 - Control and Data Processor
CDP-1-DHD - Control and Data Processor, Dual Hard Drives
PCCOWU-DHD - Operators Workstation, Dual Hard Drive


Model 6000E
(PDF, 78KB)

© 2015, Pacific Instruments, Inc. Catalog IndexPrivacy PolicySite Map